Inner page banner


SERIES PLR

DC-DC CONVERTERS

Wide Input Range/up to 3.33:1 Isolated Regulated up to 5 Watt DC-DC Converters Fully Regulated All Units Shielded

 

 

 

This series of Low Profile 0.300", high efficiency, wide input range, encapsulated regulators come in 85 different models. These units featue a 500 VOLT DC input to output isolation in both single and dual output models. The PLR Series will operate from -25º C to +70º C with no heat sink or electrical derating. These units are excellent for applications where input voltage varies dramatically, yet a high efficiency and output voltage regulation must be maintained.

TYPICAL CHARACTERISTICS:

  • Test conditions: 25º C ambient.
  • Operating temperature: -25º C to +70º C ambient.
  • Output voltage tolerance: ±1% at typical input voltage
  • Output voltage temperature coefficient: 0.02%/ºC
  • Storage temperature: -55º C to +125º C
  • Short circuit protection: Temporary
  • Operating frequency: 40 KHz, typical

OPTIONS AVAILABLE

  • Per Mil. Std. 883
  • Expanded operating temp. (-55º C to +85º C)
  • Stabilization Bake (125º C ambient)
  • Temperature Cycle (-55º C to +125º C)
  • Hi Temp, full power burn in (100% power, 125º C case temp)
 FEATURES
  • Voltage regulation over input range of

     

    Unit
    Low
    High
    PLRE
    5V
    15V
    PLRF
    8V
    24V
    PLRA
    18V
    36V
    PLRB
    36V
    60V
    PLRC
    18V
    60V

     

  • 0.300" Height
  • Encapsulated semiconductors, conservatively rated for maximum reliability.
  • Load regulation (see table for typical variation at different loads)
  • Line regulation = Typical values
  • 5-15V DC = ±1.5%
    8-24V DC = ±1.5%
    18-36V DC = ±1.0%
    36-60V DC = ±1.0%
    18-60V DC = ±1.5%
  • High efficiency - up to 80%
  • Will operate over a temperature range of -25º C to +70º C with no heat sink or electrical derating
  • 6 sided shielding
  • Isolation - 100 megohms at 500 Volts DC
  • External output trimming pin standard, +5%
  • Single and dual isolated outputs
  • Each unit is supplied with an external control pin. This "C" pin, when connected to the negative (-) input, will disable the unit, allowing for remote shutdown.

 

SERIES PLR - SINGLE OUTPUT
PICO
Part
Number
Input
Volt.
Range
Output
Volt.
DC
Max.
Load
Current
(mA)
Max.
Output
Power
(watts)
Eff. @
Full
Load
Typical
(%)*
Input
Current
Full
Load
Typical
(mA)*
Output
Volt.
Ripple@
Full LD.
1-1 MHz BW
mv p-p
Output
Volt.
Tolerance
(± %)*
**
V LD.
Reg.
25%-100%
Load
(± %)*
Line
Regu-
lation
(± %)*
Price
(US $)
PLRE3.3S
PLRE5S
PLR5.2S
PLRE9S
PLRE12S
PLRE15S
PLRE24S
PLRE28S
PLRE48S
PLRE100S
5-15
5-15
5-15
5-15
5-15
5-15
5-15
5-15
5-15
5-15
3.3
5
5.2
9
12
15
24
28
48
100
909
600
577
444
333
267
167
143
83
40
3
3
3
4
4
4
4
4
4
4
75
78
78
78
79
79
80
80
80
80
400
385
385
515
505
505
500
500
500
500
200
175
175
125
125
125
125
125
300
300
1.00
0.75
0.75
0.50
0.50
0.50
0.50
0.50
0.50
0.50
3.00
1.75
1.75
1.50
1.25
1.25
1.00
1.00
1.00
1.00
2.75
2.00
2.00
1.50
1.25
1.25
1.25
1.00
1.00
1.00
231.42
231.42
231.42
231.42
231.42
231.42
231.42
231.42
231.42
310.91
PLRF3.3S
PLRF5S
PLRF5.2S
PLRF9S
PLRF12S
PLRF15S
PLRF24S
PLRF28S
PLRF48S
PLRF100S
8-24
8-24
8-24
8-24
8-24
8-24
8-24
8-24
8-24
8-24
3.3
5
5.2
9
12
15
24
28
48
100
1212
1000
961
556
417
333
208
179
104
50
4
5
5
5
5
5
5
5
5
5
75
78
78
78
79
79
80
80
80
80
333
400
400
400
395
395
390
390
390
390
200
150
150
125
125
125
125
125
250
300
1.00
0.75
0.75
0.50
0.50
0.50
0.50
0.50
0.50
0.50
3.00
1.75
1.75
1.50
1.25
1.25
1.00
1.00
1.00
1.00
2.75
2.00
2.00
1.50
1.25
1.25
1.25
1.00
1.00
1.00
231.42
231.42
231.42
231.42
231.42
231.42
231.42
231.42
231.42

310.91
PLRA3.3S
PLRA5S
PLRA5.2S
PLRA9S
PLRA12S
PLRA15S
PLRA24S
PLRA28S
PLRA48S
PLRA100S
18-36
18-36
18-36
18-36
18-36
18-36
18-36
18-36
18-36
18-36
3.3
5
5.2
9
12
15
24
28
48
100
1212
1000
961
556
417
333
208
179
104
50
4
5
5
5
5
5
5
5
5
5
76
76
76
76
77
79
80
80
80
80
195
245
245
245
240
235
230
230
230
230
150
100
100
100
100
100
100
100
250
300
1.00
0.75
0.75
0.50
0.50
0.50
0.50
0.50
0.50
0.50
3.00
2.00
2.00
2.00
2.00
1.50
1.50
1.50
1.00
1.00
1.50
1.00
1.00
0.50
0.50
0.50
0.50
0.50
0.50
1.00
231.42
231.42
231.42
231.42
231.42
231.42
231.42
231.42
231.42

310.91
PLRB3.3S
PLRB5S
PLRB5.2S
PLRB9S
PLRB12S
PLRB15S
PLRB24S
PLRB28S
PLRB48S
PLRB100S
36-60
36-60
36-60
36-60
36-60
36-60
36-60
36-60
36-60
36-60
3.3
5
5.2
9
12
15
24
28
48
100
1212
1000
961
556
417
333
208
179
104
50
4
5
5
5
5
5
5
5
5
5
74
74
74
74
74
76
76
76
76
76
113
140
140
140
140
135
135
135
135
135
150
100
100
100
100
100
100
100
200
300
1.00
0.75
0.75
0.50
0.50
0.50
0.50
0.50
0.50
0.50
3.00
1.75
1.75
1.50
1.00
1.00
0.75
0.75
0.75
1.00
1.50
0.50
0.50
0.50
0.25
0.25
0.25
0.25
0.25
1.00
273.50
273.50
273.50
273.50
273.50
273.50
273.50
273.50
273.50
310.91
PLRC3.3S
PLRC5S
PLRC5.2S
PLRC9S
PLRC12S
PLRC15S
PLRC24S
PLRC28S
PLRC48S
PLRC100S
18-60
18-60
18-60
18-60
18-60
18-60
18-60
18-60
18-60
18-60
3.3
5
5.2
9
12
15
24
28
48
100
1212
1000
961
556
417
333
208
179
104
50
4
5
5
5
5
5
5
5
5
5
74
75
75
75
75
77
78
78
78
78
139
170
170
170
170
165
165
165
165
165
150
100
100
100
100
100
100
100
225
300
1.00
0.75
0.75
0.50
0.50
0.50
0.50
0.50
0.50
0.50
3.00
2.00
2.00
1.50
1.00
1.00
0.75
0.75
0.75
1.00
1.75
1.50
1.50
1.00
0.75
0.75
0.75
0.75
0.75
1.00
294.54
294.54
294.54
294.54
294.54
294.54
294.54
294.54
294.54
395.70
* Measurements taken with input voltage set at mid value.
**10% minimum load required.

 

 

Larger Size Drawing

 

 

SERIES PLR - DUAL OUTPUT
PICO
Part
Number
Input
Volt.
Range
Output
Volt.
DC
Per
Output
Max.
Load
Current
(mA)
Per
Output
Max.
Output
Power
(watts)
Per
Output
Eff. @
Full
Load
Typical
(%)*
Input
Current
Full
Load
Typical
(mA)*
Output
Volt.
Ripple@
Full LD.
1-1 MHz BW
mv p-p
Output
Volt.
Tolerance
(± %)*
**

V LD.
Reg.
25%-100%
Load
(± %)*
Line
Regu-
lation
(± %)*
Price
(US $)
PLRE5D
PLRE9D
PLRE12D
PLRE15D
PLRE24D
PLRE28D
PLRE48D
5-15
5-15
5-15
5-15
5-15
5-15
5-15
5
9
12
15
24
28
48
300
222
167
134
84
72
42
1.5
2.0
2.0
2.0
2.0
2.0
2.0
78
78
79
79
80
80
80
385
515
505
505
500
500
500
175
125
125
125
125
125
300
0.75
0.50
0.50
0.50
0.50
0.50
0.50
1.75
1.50
1.25
1.25
1.00
1.00
1.00
2.00
1.50
1.25
1.25
1.25
1.00
1.00
284.02
284.02
284.02
284.02
284.02
284.02
305.26
PLRF5D
PLRF9D
PLRF12D
PLRF15D
PLRF24D
PLRF28D
PLRF48D
8-24
8-24
8-24
8-24
8-24
8-24
8-24
5
9
12
15
24
28
48
500
278
208
167
104
89
52
2.5
2.5
2.5
2.5
2.5
2.5
2.5
78
78
79
79
80
80
80
400
400
395
395
390
390
390
100
125
125
125
125
125
250
0.75
0.50
0.50
0.50
0.50
0.50
0.50
1.75
1.50
1.25
1.25
1.00
1.00
1.00
2.00
1.50
1.25
1.25
1.25
1.00
1.00
284.02
284.02
284.02
284.02
284.02
284.02
305.26
PLRA5D
PLRA9D
PLRA12D
PLRA15D
PLRA24D
PLRA28D
PLRA48D
18-36
18-36
18-36
18-36
18-36
18-36
18-36
5
9
12
15
24
28
48
500
278
208
167
104
89
52
2.5
2.5
2.5
2.5
2.5
2.5
2.5
76
76
77
79
80
80
80
245
245
240
235
230
230
230
100
100
100
100
100
100
250
0.75
0.50
0.50
0.50
0.50
0.50
0.50
2.00
2.00
2.00
1.50
1.50
1.50
1.00
1.00
0.50
0.50
0.50
0.50
0.50
0.50
284.02
284.02
284.02
284.02
284.02
284.02
305.26
PLRB5D
PLRB9D
PLRB12D
PLRB15D
PLRB24D
PLRB28D
PLRB48D
36-60
36-60
36-60
36-60
36-60
36-60
36-60
5
9
12
15
24
28
48
500
278
208
167
104
89
52
2.5
2.5
2.5
2.5
2.5
2.5
2.5
74
74
74
76
76
76
76
140
140
140
135
135
135
135
100
100
100
100
100
100
200
0.75
0.50
0.50
0.50
0.50
0.50
0.50
1.75
1.50
1.00
1.00
0.75
0.75
0.75
0.50
0.50
0.25
0.25
0.25
0.25
0.25
326.10
326.10
326.10
326.10
326.10
326.10
350.48
PLRC5D
PLRC9D
PLRC12D
PLRC15D
PLRC24D
PLRC28D
PLRC48D
18-60
18-60
18-60
18-60
18-60
18-60
18-60
5
9
12
15
24
28
48
500
278
208
167
104
89
52
2.5
2.5
2.5
2.5
2.5
2.5
2.5
75
75
75
77
78
78
78
170
170
170
165
165
165
165
100
100
100
100
100
100
225
0.75
0.50
0.50
0.50
0.50
0.50
0.50
2.00
1.50
1.00
1.00
0.75
0.75
0.75
1.50
1.00
0.75
0.75
0.75
0.75
0.75
347.15
347.14
347.14
347.14
347.14
347.14
373.09
* Measurements taken with input voltage set at mid value.
** 10% minimum load required.

 

 

Larger Size Drawing
Ordering Instructions:
  • No minimum.
    Net 30 days F.O.B. Pelham, NY

    Delivery--Sample orders typically ship within two weeks

For immediate engineering assistance or to place an order:

Call Toll Free: 800-431-1064

PICO Electronics, Inc.

143 Sparks Ave. Pelham, NY 10803-1810
Tel: 914-738-1400 or Fax: 914-738-8225

Go back to DC-DC Converters menu